Dodge Ram 3500 Transmission Problems & Cost | 47RE | 48RE | 68RFE | AS68RC

The Dodge Ram 3500 was equipped with the A618 (47RE), or the 48RE in high-output Diesel models. The later model Ram 3500 Diesel has the 6-speed 68RFE, the AS68RC, or the AS69RC. But they aren’t without their problems though, so let’s look at some of the most common Dodge Ram 3500 transmission problems, look at cost estimates and figure out what you can do about them.

Need a replacement transmission? Get an estimate for replacement transmissions and local installation. Look up your transmission model by vehicle make and model.

What Transmission Do I Have?

Dodge Ram 3500 Transmission Models

Dodge Ram 2500 Transmission: A618 (47RE)
Dodge Ram 2500 Transmission: 48RE (High-Output Diesel)
Ram 2500 Transmission: 68RFE
Ram 2500 Transmission: AS68RC
Ram 2500 Transmission: AS69RC

Dodge Ram 3500 Transmission Replacement Cost Estimate

Pricing varies by model. To be 100% sure on pricing, have your VIN# handy and use our Get An Estimate feature to look up your transmission by VIN#.

Replacement Dodge Ram 3500 Transmission Prices:

What are the DTC codes related to Dodge Ram 3500 transmission problems?

Dodge Ram 3500 Transmission Recalls & Known Problems

Recall 97V084000 – Transmission cooler lines
1994 – 1997 Dodge Ram pickups equipped with V6 or V8 gasoline engines and an automatic transmission
1995 – 1997 Dodge Ram pickups equipped with the V-10 gasoline engine and an automatic transmission
1996 – 1997 Dodge Ram Van and Ram Wagon equipped with an automatic transmission
Summary – In certain operating conditions, the transmission fluid temperature can cause the plastic retainers in the transmission cooler pressure line quick connect fittings to melt.
Consequence – If this occurs, the fitting may separate engine transmission fluid could spray onto the engine and exhaust system, potentially causing a fire.
Solution – In May 1997, Dodge dealers were instructed to replace the quick connect fittings with ones that incorporated a stainless steel retainer. Chances are, this problem has already been addressed in your vehicle. However, if you’re still concerned, you can call the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236

Recall 13V-344 / N50 – AS68RC transmission snap ring recall
2012 Ram 3500 cab chassis
2012 Ram 4500/5500 cab chassis
Summary – According to the recall, the forward primary clutch drum snap ring groove on the Aisin Seiki AS68RC 6-speed automatic transmission may not have been incorrectly machined. As a result, the snap ring itself could be ejected from the groove
Consequence – If this happens, the forward primary clutch may not be able to engage gears if the snap ring is ejected. This can result in a sudden loss of power, which could lead to an accident in certain conditions.
Remedy – According to the recall, just 85 trucks were affected, and Chrysler was supposed to replace the transmissions in those trucks. However, concerned owners can contact Chrysler customer service at 1-800-853-1403. You can also contact the National Highway Traffic Safety Administration at 1-888-327-4236

Ram 3500 Technical Service Bulletins (TSB)

TSB 21-08-00 – Delayed torque converter clutch lock-up and/or a P1740 DTC – 47RE transmission
1999 – 2000 Dodge Ram 2500/3500 Cummins Diesel
Problem – On trucks that exhibit this 47RE transmission problem, there may be a noticeable lack of a transmission shift between 30 – 50 mph (38 – 80 km/h) due to a delayed torque converter clutch engagement/lockup. If and when the shift does occur, it may be unusually harsh.
Solution – A revised 47RE valve body upper housing separator plate will need to be installed (it improves fluid flow to the torque converter clutch).

TSB 21-009-07 – 1-2 shift hunt under light throttle – 48RE transmission
2004 – 2007 Ram 2500 – 2004 – 2007 Ram 3500
Problem – Engine light throttle conditions, drivers may notice that the transmission seems to hunt for a gear, or slip during the 1-2 shift.
Solution – A new 48RE governor pressure solenoid valve will be needed to fix this problem.

TSB 18-037-07 REV A – Low line pressure – 68RFE transmission
2007 Ram 2500 – 2007 Ram 3500
Problem – Drivers may experience an illuminated check engine light, with a P0868 DTC.
Solution – This may be due to a malfunctioning TCM, which may be cured with a software update.

TSB 21-010-12 – Clunk noise when shifting from drive to neutral – 68RFE transmission
2011 – 2012 Ram 1500 – 2011- 2012 Ram 2500 – 2011 – 2012 Ram 3500 Cab Chassis – 2011 – 2012 Dodge Durango – 2011 – 2012 Jeep Grand Cherokee
Problem – Drivers may notice a pronounced clunking noise when shifting from drive to neutral. This may be particularly evident when the outside temperature is hot.
Solution – These 68RFE transmission problems may be caused by the underdrive clutch releasing too quickly. To correct the issue a revised spacer plate will need to be installed inside of the valve body.

Other Dodge Ram TSBs

TSB 247853
A small number of 2008 Dodge Ram trucks were fitted with a defective shift cable that could loosen itself, preventing the driver from manually selecting low gears with the shift lever.

TSB 138954
The PCM (Powertrain Control Module) on the 2003 model contained software errors that prevented it from detecting problems with the governor pressure sensor. To fix the problem, dealers were issued a software update for the PCM.

Common Dodge Ram 3500 Transmission Problems

Premature forward clutch failure
Problem – It’s not uncommon to experience premature forward clutch failure, which can prevent the vehicle being driven.
Solution – This can be caused by a number of issues including valve body failure, a worn stator bushing, a failed forward clutch piston seal, a failed forward drum assembly, the use of power programmers/chips to increase engine output, which can overwhelm a number of internal components.

Engine RPM increase or partial engine stall when coming to a stop
Problem – Drivers may experience a sudden RPM surge when coming to a stop, which can cause difficulty holding the vehicle at a stop with the brakes. This is usually preceded by a partial engine stall, which the ECU tries to overcome by increasing the RPMs. Upon accelerating, upshift’s will feel much harder than usual. These 48RE transmission problems happen because torque converter clutch is applied, due to malfunctioning solenoids.
Solution – To correct this issue, the lockup solenoid and overdrive solenoid assembly (they’re one unit) will need to be replaced, or upgraded like they are in a remanufactured 48RE transmission.

Engine stalling in Reverse and/or Drive
Problem – The engine may stall when the vehicle is shifted into either reverse or drive.
Solution – These common 48RE transmission problems are usually caused by a stuck TCC switch valve, restricted transmission cooler lines, or torque converter failure.

Sudden shift to neutral after takeoff
68RFE transmission
Problem – Drivers may notice that the vehicle suddenly shifts into neutral after trying to pull away in Drive. There may also be a P0721 and P0933 DTC.
Solution – The 68RFE low sprag inside of the gearbox has most likely failed.

Forward movement in Low gear but not in Drive – AS69RC transmission
Problem – Drivers may not be able to get the vehicle to move when they place it into Drive. However it will move forward when manually shifted into Low gear.
Solution – It’s most likely that the F1 sprag inside of the transmission will need to be replaced. This is a common problem in vehicles that see ‘severe’ use.

Lack of Response
Leaking Fluid
Low Fluid
Burning Smell
Grinding or Shaking
Whining, Clunking or Humming
Refuses to Go Into Gear
Torque Converter Issues
Valve Body Issues
Transmission Noisy in Neutral
Gears Slipping
No 3rd or 4th Gear
No 1st or 2nd Gear
No Reverse
Dragging Clutch
Trouble Codes / Check Engine Light

Can I drive with a transmission problem?

If your Dodge Ram 3500 can still make it up and down the road, you might say “It’s fine, I’ll just drive it until I can get it fixed”. But that is not always a good idea, depending on the symptoms. You see, there are a lot of (very expensive) moving parts inside of a transmission, and if something isn’t right, continuing to drive with a transmission problem could damage something else.

How often does a Dodge Ram 3500 transmission need to be replaced?

The overall lifespan of a Dodge Ram 3500 transmission largely depends on how well it was maintained. Factory design flaws also factor into this equation, along with how/how hard you drive. But on average, we’ve seen the Dodge Ram 3500 transmission last for between 130,000-180,000 miles. A high quality replacement transmission however, can last considerably longer if all of the factory design flaws have been addressed and the vehicle has been maintained.

How are Dodge Ram 3500 transmission issues diagnosed?

It is fairly easy to guesstimate what the root cause of your Dodge Ram 3500 transmission problems might be, but you won’t truly know unless you have the right tools and experience. A good mechanic or transmission repair center will be able to connect your truck to a computer and find out which diagnostic trouble codes (DTC’s) have been stored. Once they know what to look for, they can perform a visual inspection to verify the problem.

How is a Dodge Ram 3500 transmission replaced?

In order to replace your Dodge Ram 3500 transmission, the truck has to be lifted from the ground in order to gain access to all of the parts that will need to be unbolted. Then the transmission can be lowered to the ground (typically with a transmission jack), so the new transmission can be installed.

Recommendations for Dodge Ram 3500 transmission issues?

To save time and get back on the road faster, have your 17-digit VIN# handy and you can get an online quote for a reman Dodge Ram 3500 transmission here, then find a local shop using our Find a Shop guide to install it for you.

How to Solve Dodge Ram 3500 Transmission Problems

Solution A: Buy a Used Dodge Ram 3500 Transmission

The quickest way to fix your transmission problems is to simply buy a used transmission or used transmission. These can be found at most junk yards, and they often come with a 30-90 day warranty. However, there’s no way to determine the actual condition of the internal components, so you could be spending a bunch of money to have the exact same problems. Plus, that warranty only covers the transmission if it’s defective, not the labor costs that you’ll have to pay.

Solution B: Buy a Rebuilt Dodge Ram 3500 Transmission

Another option would be a rebuilt transmission or rebuilt transmission. A local repair shop will remove your transmission, then install a bunch of new parts during the rebuild. The problem here is, the skills and experience of each transmission rebuilder will vary widely from shop to shop, so you could have problems from something that wasn’t adjusted properly. And the 1-2 year warranty might only cover you at certain transmission repair shops, in a specific geographical area.

Solution C: Buy a Remanufactured Dodge Ram 3500 Transmission

Many owners depend on their vehicle to commute and get things done. Their gasoline engines are designed to go 100’s of thousands of miles, so it makes sense to invest in a remanufactured transmission.

Need a replacement transmission? Get an estimate for replacement transmissions and local installation. Look up your transmission model by vehicle make and model.

What Transmission Do I Have?

What Problem Does Your Dodge Ram 3500 Have?

Let us know the year, mileage and problem you’re having as well as any trouble (OBD) codes you’ve found. If you’ve been given a quote or paid for a repair, we’d like to hear about that too!